Simple Steam System Helps Boost Power, Mileage

Simple Steam System Helps Boost Power Mileage ENERGY Alternative Fuels George Zimmerman uses heat from the exhaust pipe on his 350 Ford Dually to generate steam that helps power the truck A 3/8-in steel tube runs from a small water tank up the length of the truck’s vertical exhaust stack and then back down As the water turns to steam it is pulled through the tube and into the air intake between the air cleaner and the throttle It’s cheap It’s easy And the added power is noticeable “The truck runs much better than it did when I first got it and hadn’t installed the system ” says Zimmerman who warns that the modification is not for every vehicle “You need a big strong engine and the right design ” he says “The steam is delivering oxygen and hydrogen into the cylinder and it can be too powerful for a light engine ” Zimmerman knows this from personal experience The first steam power system he made went onto on a small Toyota 4-cylinder car He immediately noticed a reduction in fuel used with no reduction in power However the good times didn’t last “I was flying down the road when I heard a noise ” says Zimmerman “Smoke poured out of the engine as I pulled over ” A connecting rod had blown through the engine block Zimmerman suspects the motor couldn’t handle the hydrogen being fed into it In his next design Zimmerman went to the 1-ton truck with the vertical exhaust stack The water tank is even with the entry point of the pipe into the stack so there’s no water pressure forcing water and steam through the system “The steam is pulled into the air intake by the vacuum ” he says As the engine is accelerating more heat is moving through the stack producing more steam At the same time more vacuum pulls the increased steam through Zimmerman believes the system would work even better on a diesel engine He also is positive the system can be perfected beyond what he has done However at the age of 80 he doesn’t feel he can do it “I’ve not tried to patent it in part because I would like others to develop it and use it ” he says “I think if the trucking companies perfected it it could really set the oil companies back on their heels ” Contact: FARM SHOW Followup George Zimmerman Jr 305 S Hwy 63 Greentop Mo 63546 ph 660 216-0205 Editors note: George Zimmerman died before this story could be published It is a concept he worked on for more than 30 years blowing several engines in the process George wanted to pass on the concept to FARM SHOW readers in hopes that someone will carry on his work His son George Jr ’s contact information is at the end of the story Feel free to contact him with questions and he’ll try to help

To read the rest of this story, download this issue below or click here to register with your account number.