You have reached your limit of 5 free stories. A story preview is shown instead.
To view more stories
(If your subscription is current,
click here to Login or Register.)
Underground Grain Storage
An Australian grain farmer who needed long-term storage but couldn't justify construction of new structures went underground to come up with reliable storage at 1/5th the cost.
Wally Thorn, who farms near Glen Alice in New South Wales, dug a 79 ft. long pit that's 14 ft. wide to store about 5,500 bu. of small gra
..........
You must sign in, subscribe or renew to see the page.
You must sign in, subscribe or renew to see the flip-book
Underground Grain Storage CROP STORAGE Grain Storage 9-5-29 An Australian grain farmer who needed long-term storage but couldn't justify construction of new structures went underground to come up with reliable storage at 1/5th the cost.
Wally Thorn, who farms near Glen Alice in New South Wales, dug a 79 ft. long pit that's 14 ft. wide to store about 5,500 bu. of small grain. He figures he can store grain indefinitely in the underground bin at an initial cost far below the cost of above ground permanent structures.
"It cost about $600 to dig the pit and get to the point where it's ready to hold grain. To cover it over will cost about another $200," says Thorn, who plans to build more "pit grain bins" if his first is as successful as he hopes. "It's a cheap form of long term storage. I don't anticipate any insect damage or moisture problems."
In-ground storage of grain is not a new idea in Australia. Many farmers in the area have recollections of underground storage pits built years ago during severe droughts that were opened after 10 years or more with no sign of damage.
Alan Andrews, researcher at the Agricultural Engineering Center at Glenfield has researched the underground storage idea.
"It's certainly quite a lot cheaper than traditional methods of storing grain and, if done well, can make the grain very secure. It's fairly important to place the pit correctly. It must be on a well-drained site where water is not going to lie around," Andrews cautions.
He recommends that farmers only store small grain with a moisture content of 13% or less. He says completely wrapping the grain in plastic is probably unnecessary and he recommends just a sheet extending over the top and down the side of the pit part way. He says the layer of soil over the top of the plastic ù as much as 20 in. ù is what keeps out most pests. Pits are emptied from one end, which is left open, by tractor loaders and augers.
To read the rest of this story, download this issue below or click
here to register with your account number.
